|
| ||
|
|
||
Bioreactor Performance (bioreactor + performance)
Selected AbstractsCultivation of low-temperature (15°C), anaerobic, wastewater treatment granulesLETTERS IN APPLIED MICROBIOLOGY, Issue 4 2009J. O'Reilly Abstract Aims:, Anaerobic sludge granules underpin high-rate waste-to-energy bioreactors. Granulation is a microbiological phenomenon involving the self-immobilization of several trophic groups. Low-temperature anaerobic digestion of wastes is of intense interest because of the economic advantages of unheated bioenergy production technologies. However, low-temperature granulation of anaerobic sludge has not yet been demonstrated. The aims of this study were to (i) investigate the feasibility of anaerobic sludge granulation in cold (15°C) bioreactors and (ii) observe the development of methanogenic activity and microbial community structure in developing cold granules. Methods and Results:, One mesophilic (R1; 37°C) and two low-temperature (R2 and R3, 15°C) laboratory-scale, expanded granular sludge bed bioreactors were seeded with crushed (diameter <0·4 mm) granules and were fed a glucose-based wastewater for 194 days. Bioreactor performance was assessed by chemical oxygen demand removal, biogas production, granule growth and temporal methanogenic activity. Granulation was observed in R2 and R3 (up to 33% of the sludge). Elevated hydrogenotrophic methanogenesis was observed in psychrophilically cultivated biomass, but acetoclastic methanogenic activity was also retained. Denaturing gradient gel electrophoresis of archaeal 16S rRNA gene fragments indicated that a distinct community was associated with developing and mature granules in the low-temperature (LT) bioreactors. Conclusions:, Granulation was observed at 15°C in anaerobic bioreactors and was associated with H2/CO2 -mediated methanogenesis and distinct community structure development. Significance and Impact of the Study:, Granulation underpins high-rate anaerobic waste treatment bioreactors. Most LT bioreactor trials have employed mesophilic seed sludge, and granulation <20°C was not previously documented. [source] Perturbation-independent community development in low-temperature anaerobic biological wastewater treatment bioreactorsBIOTECHNOLOGY & BIOENGINEERING, Issue 1 2010Pádhraig Madden Abstract The reproducibility and stability of low- temperature anaerobic wastewater treatment systems undergoing transient perturbations was investigated. Three identical anaerobic expanded granular sludge bed-based bioreactors were used to degrade a volatile fatty acid and glucose-based wastewater under sub-ambient (15°C) conditions. The effect of a variety of environmental perturbations on bioreactor performance was assessed by chemical oxygen demand removal. Temporal microbial community development was monitored by denaturation gradient gel electrophoresis (DGGE) of 16S rRNA genes extracted from sludge granules. Methanogenic activity was monitored using specific methanogenic activity assays. Bioreactor performance and microbial population dynamics were each well replicated between both experimental bioreactors and the control bioreactor prior to, and after the implementation of most of the applied perturbations. Gene fingerprinting data indicated that Methanosaeta sp. were the persistent, keystone members of the archaeal community, and likely were pivotal for the physical stability and maintenance of the granular biofilms. Cluster analyses of DGGE data suggested that temporal shifts in microbial community structure were predominantly independent of the applied perturbations. Biotechnol. Bioeng. 2010;105: 79,87. © 2009 Wiley Periodicals, Inc. [source] Evaluation of a novel Bacillus strain from a north-western Spain hot spring as a source of extracellular thermostable lipaseJOURNAL OF CHEMICAL TECHNOLOGY & BIOTECHNOLOGY, Issue 10 2009Francisco J. Deive Abstract BACKGROUND: Thermophilic microorganisms are receiving significant attention as a source of useful thermostable enzymes. However, the number of known strains is still limited, and very often their most interesting biocatalysts are intracellular or membrane-bound and produced at low levels. Thus, the isolation and study of novel extracellular enzyme-producing thermophilic microorganisms is very interesting. Moreover, the assessment of bioreactor performance is crucial, given the scarce information on the large-scale culture of these strains. RESULTS: The production of a thermostable extracellular lipase in submerged cultures of a thermophilic microorganism, recently isolated in north-west Spain, was investigated. The strain was identified by 16S rDNA sequencing as belonging to genus Bacillus. The influence of operating variables (i.e. pH, temperature, aeration) on lipase biosynthesis was analysed. Enzyme production at bioreactor scale was investigated, special attention being paid to the effect of aeration and agitation rates. CONCLUSION: The best conditions for the studied process were determined in shake flasks as pH 7.0, 55 °C and high aeration levels. Also, the non-association between lipase production and cell growth was ascertained. The culture of this novel strain was successfully carried out in laboratory-scale bioreactors, thus proving its potential for further applications. Copyright © 2009 Society of Chemical Industry [source] Hydrodynamic behaviour of a full-scale anaerobic contact reactor using residence time distribution techniqueJOURNAL OF CHEMICAL TECHNOLOGY & BIOTECHNOLOGY, Issue 5 2009Isabel Capela Abstract BACKGROUND: The knowledge of the fluid pattern of full-scale anaerobic reactors is of fundamental importance for the optimisation of biological processes. High solids concentrations often lead to inefficient mixing conditions, which may reduce treatment capacity due to heterogeneity within the biomass. RESULTS: The hydrodynamic characteristics of a full-scale anaerobic contact reactor treating evaporator condensate from a sulphite pulp mill were investigated. The methodology applied was based on the residence time distribution (RTD) technique using lithium as a tracer. Different non-ideal hydraulic flow models were tested and the best model fitting RTD data was the Gamma distribution model with by-pass. It was concluded that the full-scale bioreactor presents a good degree of mixing with about 22% of non-effective volume due to the presence of high amounts of inorganic materials. CONCLUSION: As a result of this study it was possible to both improve the full-scale bioreactor performance and decrease the running costs by changes in the plant operation strategies which allowed reduction of the huge amount of inorganic materials contributing to the non-effective volume. The methodology is simple and results from a unique RTD experiment and confirms the importance of considering mixing characteristics when assessing complex full-scale treatment processes. Copyright © 2009 Society of Chemical Industry [source] Perturbation-independent community development in low-temperature anaerobic biological wastewater treatment bioreactorsBIOTECHNOLOGY & BIOENGINEERING, Issue 1 2010Pádhraig Madden Abstract The reproducibility and stability of low- temperature anaerobic wastewater treatment systems undergoing transient perturbations was investigated. Three identical anaerobic expanded granular sludge bed-based bioreactors were used to degrade a volatile fatty acid and glucose-based wastewater under sub-ambient (15°C) conditions. The effect of a variety of environmental perturbations on bioreactor performance was assessed by chemical oxygen demand removal. Temporal microbial community development was monitored by denaturation gradient gel electrophoresis (DGGE) of 16S rRNA genes extracted from sludge granules. Methanogenic activity was monitored using specific methanogenic activity assays. Bioreactor performance and microbial population dynamics were each well replicated between both experimental bioreactors and the control bioreactor prior to, and after the implementation of most of the applied perturbations. Gene fingerprinting data indicated that Methanosaeta sp. were the persistent, keystone members of the archaeal community, and likely were pivotal for the physical stability and maintenance of the granular biofilms. Cluster analyses of DGGE data suggested that temporal shifts in microbial community structure were predominantly independent of the applied perturbations. Biotechnol. Bioeng. 2010;105: 79,87. © 2009 Wiley Periodicals, Inc. [source] | ||||||||||