Home About us Contact
|
Home About us Contact | ||
|
|
||
Processing Treatments (processing + treatment)
Selected AbstractsDigestibility and growth performance of juvenile rainbow trout (Oncorhynchus mykiss) fed with pea and canola productsAQUACULTURE NUTRITION, Issue 2 2003D.L. Thiessen A digestibility experiment and subsequent 84-day feeding experiment evaluated the use of pea and canola meal products in diets for rainbow trout. The effect of milling and heat treatment on nutrient, dry matter and energy digestibility of raw/whole peas, raw/dehulled peas, extruded/dehulled peas and autoclaved air-classified pea protein was determined. Digestibility of the protein component was uniformly high for all pea ingredients (90.9,94.6%), regardless of the processing treatment. Autoclaving or extrusion increased starch digestibility by 41,75% (P , 0.05), which consequently increased energy and dry matter digestibility of whole and dehulled peas. Autoclaved air-classified pea protein had superior protein (94.6%), energy (87.0%) and dry matter (84.0%) digestibility (P , 0.05). It was demonstrated that inclusion of 25% dehulled peas, 20% air-classified pea protein or 20% canola meal fines was feasible in trout diets allowing for replacement of soya bean meal. The data showed no difference (P , 0.05) in feed intake, final weight and specific growth rate (SGR) measurements, and feed utilization was not compromised with inclusion of pea or canola meal products as the primary plant ingredient. It was concluded that dehulled peas, air-classified pea protein and canola meal fines are suitable ingredients for use in trout diet formulation at a level of 20%. [source] USE OF CLARIFYING AGENTS AND ULTRA FILTER TO DECREASE FUMARIC ACID, HMF AND INCREASE CLARITY OF APPLE JUICEJOURNAL OF FOOD QUALITY, Issue 3 2006YAHYA TULEK ABSTRACT In this study, the effects of eight different processing treatments of apple juice (AJ) production (Process 1: Ultra filtration [UF], Process 2: Activated charcoal [AC], Process 3: polyvinylpolypyrolidone [PVPP], Process 4: Gelatine [G] + Bentonite [B], Process 5: [G + B] + UF, Process 6: [G + B] + AC, Process 7: [G + B] + PVPP and Process 8: [G + B] + Kieselguhr [K]) on the fumaric acid (FA), hydroxymethylfurfural (HMF), color and clearness values of AJ were investigated. With the exception of Processes 1 and 5, AC, K, PVPP, G and B were used at various doses in other processes. FA, HMF, color and clearness values of control sample were determined as 3.24 mg/L, 3.84 mg/L, 48.5 (%T) and 94.1 (%T), respectively. The highest proportional decrement in FA and HMF values of the samples were observed with Process 6 at the level of 5. The fifth level of Process 6 resulted in 35.8% (3.24,2.08 mg/L) and 35.9% (3.84 to 2.46 mg/L) reductions in FA and HMF values, respectively. On the other hand, the best improvement in clearness of AJ was obtained with Process 6 at the fourth level and obtained as 98.9 (%T). [source] Onion Cells After High Pressure and Thermal Processing: Comparison of Membrane Integrity Changes Using Different Analytical Methods and Impact on Tissue TextureJOURNAL OF FOOD SCIENCE, Issue 7 2010Maria E. Gonzalez Abstract:, Two different analytical methods were evaluated for their capacity to provide quantitative information on onion cell membrane permeability and integrity after high pressure and thermal processing and to study the impact of these processing treatments on cell compartmentalization and texture quality. To determine changes in cell membrane permeability and/or integrity the methodologies utilized were: (1) measurement of a biochemical product, pyruvate, formed as a result of membrane permeabilization followed by enzymatic activity and (2) leakage of electrolytes into solution. These results were compared to previously determined methods that quantified cell viability and 1H-NMR T2 of onions. These methods allowed for the monitoring of changes in the plasma and tonoplast membranes after high pressure or thermal processing. High pressure treatments consisted of 5 min holding times at 50, 100, 200, 300, or 600 MPa. Thermal treatments consisted of 30 min water bath exposure to 40, 50, 60, 70, or 90 °C. There was strong agreement between the methods in the determination of the ranges of high pressure and temperature that induce changes in the integrity of the plasma and tonoplast membranes. Membrane rupture could clearly be identified at 300 MPa and above in high pressure treatments and at 60 °C and above in the thermal treatments. Membrane destabilization effects could already be visualized following the 200 MPa and 50 °C treatments. The texture of onions was influenced by the state of the membranes and was abruptly modified once membrane integrity was lost. Practical Application:, In this study, we used chemical, biochemical, and histological techniques to obtain information on cell membrane permeability and onion tissue integrity after high pressure and thermal processing. Because there was strong agreement between the various methods used, it is possible to implement something relatively simple, such as ion leakage, into routine quality assurance measurements to determine the severity of preservation methods and the shelf life of processed vegetables. [source] Antioxidative Ability, Dioscorin Stability, and the Quality of Yam Chips from Various Yam Species as Affected by Processing MethodJOURNAL OF FOOD SCIENCE, Issue 2 2009Y.-M. Liu ABSTRACT:, The antioxidative ability, stability of storage protein dioscorin, and the quality of fried yam chips from different cultivars of Chinese yams influenced by various processing treatments were investigated. Total phenolic content and DPPH free radical scavenging effect were found to be the highest in Mingchien (MC) and the lowest in Keelung (KL) yam. Following processing, freeze-dried yams of all varieties showed the least decrease in total phenolic compounds and DPPH radical scavenging effect, while boiling caused the greatest decrease in both. Fresh yams of all varieties contained the highest dioscorin contents comparing with their counterparts. Boiling and deep-frying caused severe protein denaturation resulting in loss of dioscorin solubility after purification. Freeze-drying resulted in increase in protein surface hydrophobicity (So); nonetheless, it attained higher total phenol content, antioxidative capacity, and dioscorin stability of yams compared with other processing treatments. The peroxide values of all yam chips increased during the initial stage, then declined with advanced storage. Fracturability of all yam chips gradually decreased, due to the absorption of moisture, with increasing storage time. [source] Influence of Pressing Method on Juice Stilbene Content in Muscadine and Bunch GrapesJOURNAL OF FOOD SCIENCE, Issue 4 2008M.R. Leblanc ABSTRACT:, Juice stilbene contents of 2 muscadine (Vitis rotundifolia) cultivars, Noble and Carlos, and 2 bunch grape (Vitis labrusca) cultivars, Mid South and Miss Blanc were evaluated after crushing and pressing. Four commercial pressing methods were used to produce juice: (1) cold press of fresh berries (CP); (2) hot press of fresh berries (HP); (3) cold press of frozen and thawed berries (FCP); and (4) cold press of pectolytic enzyme treated berries (ECP). Free run juice (FRJ) from the crusher without pressing was also tested. An HPLC with a UV detector was used to verify the presence and quantity of resveratrol, piceid, and their isomers. For the muscadine juices, total stilbenes were greater for HP and FCP than for FRJ and CP treatments. Trans -resveratrol was only detected in HP juices of the muscadines at levels near the detection limits. The bunch grape cultivars behaved similar to the muscadines in the processing treatments. HP juice had the greatest total stilbene levels and was significantly greater than FRJ, CP, and FCP. Total stilbene levels in juices from the 2 bunch grape cultivars, were higher (up to 5 times greater depending on pressing method) than for the muscadine grape cultivars. Total stilbene levels in muscadine juices treated with pectinase before pressing (ECP) were similar to those of the FCP samples. Juice from FCP and ECP treated Noble muscadine had total stilbene levels greater than FRJ and CP but less than HP levels. Juices from HP-, ECP-, and FCP-treated Carlos muscadine had total stilbene levels greater than for FRJ and CP juices. [source] Effects of Vegetable Juice Powder Concentration and Storage Time on Some Chemical and Sensory Quality Attributes of Uncured, Emulsified Cooked SausagesJOURNAL OF FOOD SCIENCE, Issue 5 2007J.J. Sindelar ABSTRACT:, Uncured, no-nitrate/nitrite-added meat products can be manufactured with vegetable juice powder (VJP) and a starter culture containing Staphylococcus carnosus, resulting in quality and sensory attributes similar to traditional cured products. The 1st objective of this study was to determine the effects of varying concentrations of VJP and incubation times (MIN-HOLD) on quality characteristics, including lipid oxidation, color, and cured meat pigment concentrations, of emulsified-frankfurter-style-cooked (EFSC) sausages over a 90-d storage period. The 2nd objective was to compare residual nitrate and nitrite content resulting from different processing treatments and the 3rd objective was to assess sensory properties of finished products. Four EFSC sausage treatments (TRT) (TRT 1: 0.20% VJP, 30 MIN-HOLD; TRT 2: 0.20% VJP, 120 MIN-HOLD; TRT 3: 0.40% VJP, 30 MIN-HOLD; TRT 4: 0.40% VJP, 120 MIN-HOLD) and a sodium nitrite-added control (C) were used for this study. No differences for lipid oxidation (TBARS) between any TRTs and C or over time were observed. No differences (P > 0.05) for CIE L* values were found between TRTs. CIE a* and reflectance ratio values revealed that TRTs 2, 4, and C were redder than TRTs 1 and 3 at day 0. Trained sensory intensity ratings for cured aroma, cured color, cured flavor, uniform color, and firmness determined that all but TRT 1 were similar to C. These results indicate a longer incubation time (120 compared with 30 min) was found more critical than VJP level (0.20% or 0.40%) to result in products comparable to a sodium nitrite-added control. [source] | ||||||||||