Home  About us  Contact
 

Olive Stones (olive + stone)

Distribution by Scientific Domains
Chemistry100%

Selected Abstracts

Fermentation of enzymatic hydrolysates from olive stones by Pachysolen tannophilus

JOURNAL OF CHEMICAL TECHNOLOGY & BIOTECHNOLOGY, Issue 3 2009
Manuel Cuevas
Abstract BACKGROUND: Olive stones were pretreated with liquid hot water (LHW or autohydrolysis) at maximum temperatures between 175 and 225 °C (severity factors, logR0, between 2.73 and 4.39) to be subjected (both liquid and solid components) afterwards to enzymatic hydrolysis with cellulases from Trichoderma viride. Ethanol fermentation of hydrolysates was performed with the non-traditional yeast Pachysolen tannophilus ATCC 32691. RESULTS: After the enzymatic step, yields of hemicellulose solubilization reached 100%, while the cellulose was only partially hydrolysed (23%, logR0 = 4.39). The maximum yields in total reducing sugars and acetic acid, at the upper end of the severity range, was close to 0.25 and 0.04 g g,1 dry stone, respectively. During the fermentation stage, the increase in R0 reduced the maximum specific growth rate, biomass productivity, and overall biomass yield. The overall yields of ethanol and xylitol ranged, respectively, from 0.18 to 0.25 g g,1 and from 0.01 to 0.13 g g,1. CONCLUSIONS: The results demonstrate the possibility of producing ethanol from olive stones, making use of the cellulose and hemicellulose fraction of the waste. It was confirmed that the overall yield in xylitol strongly depended on severity factor, while the overall yield in ethanol remained practically constant for all the pretreatment conditions tested. Copyright © 2008 Society of Chemical Industry [source]

Kinetic study of the decomposition of 2-butanol on carbon-based acid catalyst

AICHE JOURNAL, Issue 6 2010
J. Bedia
Abstract The catalytic conversion of 2-butanol on a carbon-based acid catalyst prepared by chemical activation of olive stone with phosphoric acid was investigated. The carbon catalyst showed a considerable amount of surface phosphorus, presumably in form of phosphate groups, as revealed by XPS, despite a washing step carried out after the activation process. Conversion of 2-butanol yields mainly dehydration products, mostly cis-2-butene and trans-2-butene with lower amounts of 1-butene, and a very small amount of mek as dehydrogenation product. Kinetic interpretation of the experimental data was performed using two elimination mechanisms for the dehydration reaction; an E1-mechanism (two-step mechanism) and an E2-mechanism (one-step mechanism). The rate expressions derived from both models fit properly the experimental results, suggesting that probably the two mechanisms occur simultaneously. This is supported by the similar rate constant obtained for the formation of the carbocation and the olefins in the E1 and E2 mechanisms, respectively. © 2009 American Institute of Chemical Engineers AIChE J, 2010 [source]

Fermentation of enzymatic hydrolysates from olive stones by Pachysolen tannophilus

JOURNAL OF CHEMICAL TECHNOLOGY & BIOTECHNOLOGY, Issue 3 2009
Manuel Cuevas
Abstract BACKGROUND: Olive stones were pretreated with liquid hot water (LHW or autohydrolysis) at maximum temperatures between 175 and 225 °C (severity factors, logR0, between 2.73 and 4.39) to be subjected (both liquid and solid components) afterwards to enzymatic hydrolysis with cellulases from Trichoderma viride. Ethanol fermentation of hydrolysates was performed with the non-traditional yeast Pachysolen tannophilus ATCC 32691. RESULTS: After the enzymatic step, yields of hemicellulose solubilization reached 100%, while the cellulose was only partially hydrolysed (23%, logR0 = 4.39). The maximum yields in total reducing sugars and acetic acid, at the upper end of the severity range, was close to 0.25 and 0.04 g g,1 dry stone, respectively. During the fermentation stage, the increase in R0 reduced the maximum specific growth rate, biomass productivity, and overall biomass yield. The overall yields of ethanol and xylitol ranged, respectively, from 0.18 to 0.25 g g,1 and from 0.01 to 0.13 g g,1. CONCLUSIONS: The results demonstrate the possibility of producing ethanol from olive stones, making use of the cellulose and hemicellulose fraction of the waste. It was confirmed that the overall yield in xylitol strongly depended on severity factor, while the overall yield in ethanol remained practically constant for all the pretreatment conditions tested. Copyright © 2008 Society of Chemical Industry [source]