Apple Cubes (apple + cube)

Distribution by Scientific Domains


Selected Abstracts


REUSE OF SUCROSE SYRUP IN PILOT-SCALE OSMOTIC DEHYDRATION OF APPLE CUBES

JOURNAL OF FOOD PROCESS ENGINEERING, Issue 2 2002
A. VALDEZ-FRAGOSO
ABSTRACT Osmotic dehydration (OD) treatments of apple cubes were carried out in a pilot plant, which consisted of an OD vessel, a filter, a vacuum evaporator, and recirculating pumps. The osmotic solution (OS) was maintained at 59.5 ± 1.5 °Brix and 50C by reconcentration in the evaporator, and suspended particles were eliminated by filtration. OS was reused to process 20 batches of apple cubes, maintaining a constant OS/fruit ratio of 5/1 (w/w) by addition of new OS. Evolution of pH, titratable acidity, soluble solids, water activity, color, reducing sugars, and microbial load in the OS was evaluated along the OD process. The OD parameters and the apple color were determined. Values of the physicochemical properties of the OS stabilized after 10 treated batches. A microbial load of 2590 ± 330 CFU/mL was observed in the OS at the end of 20 OD treatments. Water loss, solids gain and color of dehydrated apple cubesobtained in OD process with reuse of the OS were similar to those found in an OD process carried out with a nonrewed OS. [source]


Microwave and convective dehydration of ethanol treated and frozen apple , physical properties and drying kinetics

INTERNATIONAL JOURNAL OF FOOD SCIENCE & TECHNOLOGY, Issue 6 2002
Tomas Funebo
The objective of this study was to examine how the drying kinetics and physical properties of apples are affected by pre-treatment with 95% ethanol or freezing at ,18 °C before microwave-assisted air dehydration at 50, 60 and 70 °C. Microwave heating was used to obtain these temperatures in the centre of the apple cubes. After dehydration the shrinkage and rehydration capacity were measured. The texture of dehydrated and rehydrated samples was analysed with a puncture test in a texture analyser. Samples were also analysed with confocal laser scanning microscopy to determine the correlation between physical and microstructural properties. Diffusivity in the different dehydration processes was calculated. Ethanol-treated apples showed both high rehydration and high effective rehydration capacity compared with the other samples. Freezing before dehydration increased the diffusivity and reduced the firmness of rehydrated apples compared with no pre-treatment. [source]


REUSE OF SUCROSE SYRUP IN PILOT-SCALE OSMOTIC DEHYDRATION OF APPLE CUBES

JOURNAL OF FOOD PROCESS ENGINEERING, Issue 2 2002
A. VALDEZ-FRAGOSO
ABSTRACT Osmotic dehydration (OD) treatments of apple cubes were carried out in a pilot plant, which consisted of an OD vessel, a filter, a vacuum evaporator, and recirculating pumps. The osmotic solution (OS) was maintained at 59.5 ± 1.5 °Brix and 50C by reconcentration in the evaporator, and suspended particles were eliminated by filtration. OS was reused to process 20 batches of apple cubes, maintaining a constant OS/fruit ratio of 5/1 (w/w) by addition of new OS. Evolution of pH, titratable acidity, soluble solids, water activity, color, reducing sugars, and microbial load in the OS was evaluated along the OD process. The OD parameters and the apple color were determined. Values of the physicochemical properties of the OS stabilized after 10 treated batches. A microbial load of 2590 ± 330 CFU/mL was observed in the OS at the end of 20 OD treatments. Water loss, solids gain and color of dehydrated apple cubesobtained in OD process with reuse of the OS were similar to those found in an OD process carried out with a nonrewed OS. [source]


POLYPHENOLOXIDASE ACTIVITY OF MINIMALLY PROCESSED ,JONAGORED' APPLES (MALUS DOMESTICA)

JOURNAL OF FOOD PROCESSING AND PRESERVATION, Issue 1 2005
A.M.C.N. ROCHA
ABSTRACT The influence of three chemical dips using ascorbic acid (AA), citric acid (CA) and calcium chloride (CC) on the polyphenoloxidase (PPO) activity and on the total phenolic content of minimally processed (MP) apple (Malus domestica, cv. Jonagored) during cold storage was evaluated and a potential relationship with enzymatic browning was investigated. An ascorbic acid dip (42.6 mM) of 5 min duration was the most efficient chemical treatment in reducing the PPO activity of apple cubes. A 92% inhibition was achieved after 7 days of storage at 4C. All treatments were advantageous in comparison to the control in reducing color changes. Color changes, determined by absorbance at 420 nm (soluble pigments) and lightness (L) (insoluble pigments) of apple cubes treated with ascorbic acid were correlated with total phenolic content. No correlation was observed between PPO activity and tristimulus color parameters, browning index or total phenolic content of AA-treated apple cubes. [source]


EFFECTS of CONTROLLED ATMOSPHERE ON QUALITY of MINIMALLY PROCESSED APPLE (cv. JONAGORED)

JOURNAL OF FOOD PROCESSING AND PRESERVATION, Issue 6 2000
ADA MARGARIDA CORREIA NUNES ROCHA
Controlled atmosphere (2% O2+ 4% to 12% CO2) storage was found to be advantageous over air storage in terms of overall preservation of fresh-cut apple (cv. Jonagored). After 3 days, CA-stored apple cubes were firmer, showed better color and higher content of fructose and soluble solids content than air-stored cubes. In relation to color preservation this benefit was increased when CO2 in the atmosphere was increased to 12% CO2. Controlled atmosphere storage showed no advantage over air storage in relation to sensory evaluation of firmness and flavor. [source]


EFFECT OF CaCl2 AND CONVECTIVE-OSMOTIC DRYING ON TEXTURE AND PREFERENCE OF APPLE

JOURNAL OF FOOD QUALITY, Issue 6 2006
L.A. OCHOA-MARTÍNEZ
ABSTRACT Conventional air-drying combined with osmotic dehydration was researched as a potential method for drying apple cubes of superior quality. Samples were pretreated with CaCl2 at different temperatures and times. Pretreated apple cubes were dehydrated in a tray dryer. Then, osmotic dehydration with sucrose solutions was carried out. The curves for osmotic dehydration showed that the gain of solids was higher when 40% of water was removed by convective drying while the loss of weight was lower at the same level of dehydration at 65°Brix. Texture measurements indicated that the temperature of pretreatment affected the hardness and cohesiveness. Hardness values were higher at 40C, while cohesiveness values were lower at the same temperature. The CaCl2 at a given temperature did not have a significant effect on texture. Sensory evaluation showed that samples pretreated at 25C and osmotically dried at 50°Brix had the higher preference by the judges. [source]