Home About us Contact
|
Home About us Contact | ||
|
|
||
Liquid Hot Water (liquid + hot_water)
Selected AbstractsFermentation of enzymatic hydrolysates from olive stones by Pachysolen tannophilusJOURNAL OF CHEMICAL TECHNOLOGY & BIOTECHNOLOGY, Issue 3 2009Manuel Cuevas Abstract BACKGROUND: Olive stones were pretreated with liquid hot water (LHW or autohydrolysis) at maximum temperatures between 175 and 225 °C (severity factors, logR0, between 2.73 and 4.39) to be subjected (both liquid and solid components) afterwards to enzymatic hydrolysis with cellulases from Trichoderma viride. Ethanol fermentation of hydrolysates was performed with the non-traditional yeast Pachysolen tannophilus ATCC 32691. RESULTS: After the enzymatic step, yields of hemicellulose solubilization reached 100%, while the cellulose was only partially hydrolysed (23%, logR0 = 4.39). The maximum yields in total reducing sugars and acetic acid, at the upper end of the severity range, was close to 0.25 and 0.04 g g,1 dry stone, respectively. During the fermentation stage, the increase in R0 reduced the maximum specific growth rate, biomass productivity, and overall biomass yield. The overall yields of ethanol and xylitol ranged, respectively, from 0.18 to 0.25 g g,1 and from 0.01 to 0.13 g g,1. CONCLUSIONS: The results demonstrate the possibility of producing ethanol from olive stones, making use of the cellulose and hemicellulose fraction of the waste. It was confirmed that the overall yield in xylitol strongly depended on severity factor, while the overall yield in ethanol remained practically constant for all the pretreatment conditions tested. Copyright © 2008 Society of Chemical Industry [source] Effect of varying feedstock,pretreatment chemistry combinations on the formation and accumulation of potentially inhibitory degradation products in biomass hydrolysatesBIOTECHNOLOGY & BIOENGINEERING, Issue 3 2010Bowen Du Abstract A variety of potentially inhibitory degradation products are produced during pretreatment of lignocellulosic biomass. Qualitative and quantitative interrogation of pretreatment hydrolysates is paramount to identifying potential correlations between pretreatment chemistries and microbial inhibition in downstream bioconversion processes. In the present study, corn stover, poplar, and pine feedstocks were pretreated under eight different chemical conditions, which are representative of leading pretreatment processes. Pretreatment processes included: 0.7% H2SO4, 0.07% H2SO4, liquid hot water, neutral buffer solution, aqueous ammonia, lime, lime with oxygen pressurization, and wet oxidation. Forty lignocellulosic degradation products resulting from pretreatment were analyzed using high performance liquid chromatography in combination with UV spectroscopy or tandem mass spectrometry detection (HPLC-PDA-MS/MS) and ion chromatography (IC). Of these compounds, several have been reported to be inhibitory, including furfural, hydroxymethyl furfural, ferulic acid, 3,4-dihydroxybenzaldehyde, syringic acid among others. Formation and accumulation of monitored compounds in hydrolysates is demonstrated to be a function of both the feedstock and pretreatment conditions utilized. Biotechnol. Bioeng. 2010;107: 430,440. © 2010 Wiley Periodicals, Inc. [source] Enzymatic digestion of liquid hot water pretreated hybrid poplarBIOTECHNOLOGY PROGRESS, Issue 2 2009Youngmi Kim Abstract Liquid hot (LHW) water pretreatment (LHW) of lignocellulosic material enhances enzymatic conversion of cellulose to glucose by solubilizing hemicellulose fraction of the biomass, while leaving the cellulose more reactive and accessible to cellulase enzymes. Within the range of pretreatment conditions tested in this study, the optimized LHW pretreatment conditions for a 15% (wt/vol) slurry of hybrid poplar were found to be 200oC, 10 min, which resulted in the highest fermentable sugar yield with minimal formation of sugar decomposition products during the pretreatment. The LHW pretreatment solubilized 62% of hemicellulose as soluble oligomers. Hot-washing of the pretreated poplar slurry increased the efficiency of hydrolysis by doubling the yield of glucose for a given enzyme dose. The 15% (wt/vol) slurry of hybrid poplar, pretreated at the optimal conditions and hot-washed, resulted in 54% glucose yield by 15 FPU cellulase per gram glucan after 120 h. The hydrolysate contained 56 g/L glucose and 12 g/L xylose. The effect of cellulase loading on the enzymatic digestibility of the pretreated poplar is also reported. Total monomeric sugar yield (glucose and xylose) reached 67% after 72 h of hydrolysis when 40 FPU cellulase per gram glucan were used. An overall mass balance of the poplar-to-ethanol process was established based on the experimentally determined composition and hydrolysis efficiencies of the liquid hot water pretreated poplar. © 2009 American Institute of Chemical Engineers Biotechnol. Prog., 2009 [source] | ||||||||||